New Auto AC Compressor For MAZDA 3 2004 MAZDA 5 2010 2.0L 2.3L 140162C 140639C

Description

Document
NOTE: Each AC air compressor comes with 100ML of Oil. You dont need to add oil additionally.
How often do AC compressors need to be replaced?
Failure of the air conditioning compressor is common because moisture or clogs in the air conditioning system will place
high stress on the compressor. Compressor clutch failure is much more common on older vehicles, but some modern compressors still utilize an A/C compressor clutch to turn the compressor on and off. In general, A/C compressors tend to
fail after 60,000-70,000 miles, but that time may be lengthened depending on use, demand, and operating conditions.
Installation Step
1. Once the old compressor has been removed, begin by removing the receiver/drier or accumulator, and the expansion valve or orifice tube from the vehicle.
2. Next, flush the condenser and evaporator using a non-oil based A/C flush. The valve must be removed on expansion valve system before the evaporator can be flushed.
· Flush evaporators from inlet to outlet.
3. Install the new receiver drier or accumulator, and new expansion valve or orifice tube.
4. Next, install the new or remanufactured A/C Compressor.
5. Install and tighten the A/C Compressor mounting bolts.
6. Reconnect any electrical connectors to the A/C Compressor.
7. Re-install the refrigerant lines and A/C belt to the A/C Compressor.
8. Reconnect the negative battery cable.
9. Evacuate the A/C system with an A/C servicing machine for at least one hour.
10. Check the system for leaks.
11. If there are no leaks, install the refrigerant charge (Check the A/C system sticker under the hood of the vehicle for the proper amount and type of refrigerant for the system). Then, let the system set for 2 minutes. Doing so will allow the refrigerant to carry the oil and spread more evenly throughout the system.
12. Start the vehicle’s engine and turn on the A/C system.
To confirm that this part fits your vehicle, enter your vehicle's Year, Make, Model, Trim and Engine in the Compatibility Table.
Pay attention：
This compressor comes pre-filled with the correct amount of oil(100ml).
Thus, there is no need to add any additional oil to your system.
Please add refrigerant to 70-80% without filling up.
There may be noise if the refrigerant is added too much.
Installation fee is not on seller .
Package includes:
1  A/C Compressor
（Professional Installer is Highly Recommended ）
Shipping
The shipping rates listed are only for residential or commercial destinations in the continental 48 United States. All international sales will go through eBay Global Shipping Program.Please ask us if there are any questions.
We only ship the item to the address that is sent to us at the time of checkout. Please verify the correct shipping address in your PayPal account before making your payment. If we ship your item to an old or invalid address and you are not able to locate the item, we are not responsible for shipping a replacement.
Currently, we do not ship to Hawaii, Alaska, Puerto Rico,APO/FPO/PO Boxes.
We use USPS, UPS & FedEx as shipping method.
Payments cleared before 12 PM PST, will be shipped on the same day.
Payment
We accept PayPal and all forms of credit card.
We will only ship to the confirmed Paypal shipping address given with the payment.
We do not offer local pick up service.
Return
30 days Money Back Guarantee.
If any package that needs to be returned, please contact our customer service first to receive a RMA form.
All return items MUST be in brand new condition.
About Us
Specialized in aftermarket auto parts since 2012, we source and work directly with professional manufacturers to provide the highest quality parts at the most economical prices.
We also has over 5 years of shipping experience with FedEx and USPS . Our packing quality is guarantee ,item shipping is timely!
Document
NOTE: Each AC air compressor comes with 100ML of Oil. You dont need to add oil additionally.
INSTALLING THE NEW or REMANUFACTURED A/C COMPRESSOR
Attention Please:
Be sure to clean the air conditioning system before installation, otherwise it will cause compression broken.
1. Once the old compressor has been removed, begin by removing the receiver/drier or accumulator, and the expansion valve or orifice tube from the vehicle.
2. Next, flush the condenser and evaporator using a non-oil based A/C flush. The valve must be removed on expansion valve system before the evaporator can be flushed.
· Flush evaporators from inlet to outlet.
NOTE:
Condensers produced from 1990 – present are extremely difficult to clean. As a result, if the compressor had a major failure, it is recommended that the condenser be replaced.
3. This compressor comes pre-filled with the correct amount of oil. Thus, there is no need to add any additional oil to your system.
4. Install the new receiver drier or accumulator, and new expansion valve or orifice tube.
5. Next, install the new or remanufactured A/C Compressor.
6. Install and tighten the A/C Compressor mounting bolts.
7. Reconnect any electrical connectors to the A/C Compressor.
8. Re-install the refrigerant lines and A/C belt to the A/C Compressor.
9. Reconnect the negative battery cable.
10. Evacuate the A/C system with an A/C servicing machine for at least one hour.
11. Check the system for leaks.
12. If there are no leaks, install the refrigerant charge (Check the A/C system sticker under the hood of the vehicle for the proper amount and type of refrigerant for the system). Then, let the system set for 2 minutes. Doing so will allow the refrigerant to carry the oil and spread more evenly throughout the system.
13. Start the vehicle’s engine and turn on the A/C system.
To confirm that this part fits your vehicle, enter your vehicle's Year, Make, Model, Trim and Engine in the Compatibility Table.
Fitments:
Only fit 2.5L
AUDI
TT
2012-2013
VOLKSWAGEN
BEETLE
2006-2014
VOLKSWAGEN
BEETLE CABRIO 2010
VOLKSWAGEN
GOLF
2010-2014
VOLKSWAGEN
JETTA
2005-2014
VOLKSWAGEN
PASSAT
2012-2014
VOLKSWAGEN
R32
2008
VOLKSWAGEN
RABBIT
2006-2009
OE:CO 4574JC
Package includes:
1  A/C Compressor
Shipping
The shipping rates listed are only for residential or commercial destinations in the continental 48 United States. All international sales will go through eBay Global Shipping Program.Please ask us if there are any questions.
We only ship the item to the address that is sent to us at the time of checkout. Please verify the correct shipping address in your PayPal account before making your payment. If we ship your item to an old or invalid address and you are not able to locate the item, we are not responsible for shipping a replacement.
Currently, we do not ship to Hawaii, Alaska, Puerto Rico,APO/FPO/PO Boxes.
We use USPS, UPS & FedEx as shipping method.
Payments cleared before 12 PM PST, will be shipped on the same day.
Payment
We accept PayPal and all forms of credit card.
We will only ship to the confirmed Paypal shipping address given with the payment.
We do not offer local pick up service.
Return
30 days Money Back Guarantee.
If any package that needs to be returned, please contact our customer service first to receive a RMA form.
All return items MUST be in brand new condition.
About Us
Specialized in aftermarket auto parts since 2012, we source and work directly with professional manufacturers to provide the highest quality parts at the most economical prices.
We also has over 5 years of shipping experience with FedEx and USPS . Our packing quality is guarantee ,item shipping is timely!